Military aircraft· Cold War· 1951 – 1978

Boeing KC-97

1950 tanker aircraft series

The Boeing KC-97 Stratofreighter is a four-engined, piston-powered United States strategic tanker aircraft based on the Boeing C-97 Stratofreighter. It replaced the KB-29 and was succeeded by the Boeing KC-135 Stratotanker.

== Design and development == The KC-97 Stratofreighter was an aerial refueling tanker variant of the C-97 Stratofreighter (which was itself based on the Boeing B-29 Superfortress), greatly modified with all the necessary tanks, plumbing, and a flying boom first developed for the KB-29 bomber. The cavernous upper deck was capable of accommodating oversize cargo accessed through a very large right-side door. Transferable jet fuel was contained in tanks on the lower deck (G-L models). Both decks were heated and pressurized for high altitude operations. The boom operator lay prone, viewing operations through a window at the bottom of the tail, a configuration later used on the KC-135.

Note: Occasionally the KC-97 has been referred to as "Stratotanker". However, all reputable sources refer to the KC-97 as Stratofreighter, not -tanker. This includes both Boeing and the USAF themselves.

Operational history

The USAF began operating the KC-97 in 1950. It received 811 KC-97s from Boeing, and 74 of the C-97 cargo version, while ordering 819 KC-97s and 74 C-97s. The KC-97 carried aviation gasoline for its own piston engines and carried jet fuel for its refueling mission. This required an independent system for each type of fuel. In an emergency, it was able to offload its aviation gas to a receiver in a procedure universally known as a "save". These tankers were vitally important to the world-wide Boeing B-47 Stratojet strategic operations. An example was the support of Arctic reconnaissance flights from Thule Air Base. During Operation Creek Party, which started in 1967 and lasted for 10 years, Air National Guard and Air Force Reserve tankers supported active duty USAF and NATO units in Europe, including an 160th Air Refueling Group Ohio Air National Guard KC-97L. While it was an effective tanker, the KC-97's slow speed and low operational altitude complicated refueling operations with jet aircraft. B-52s typically lowered their flaps and rear landing gear to slow the aircraft enough to refuel from the KC-97. A typical B-52 refueling engagement profile would involve a descent that allowed the aircraft pair to maintain a higher airspeed (220–240 knots). In the early 1960s, the Tactical Air Command added General Electric J47 two twin- jet pods from retired KB-50 aerial tankers, to produce the KC-97L. These jet pods increased the speed of the KC-97 for short periods of time, and made it more compatible with jet fighter planes like the F-84, F-100, and F-101. In 1956, the Strategic Air Command began phasing out its KC-97s in favor of the KC-135 Stratotanker. KC-97s continued flying with Tactical Air Command, the Air Force Reserve, and the Air National Guard. The rest of the KC-97s were retired completely in 1978, when the Texas Air National Guard and the Utah Air National Guard exchanged their KC-97Ls for the C-130 Hercules and the KC-135 Stratotanker, respectively. One KC-97 airframe (AF Ser. No. 52-0828) was adapted into the Aero Spacelines Super Guppy, a transport plane designed to carry Apollo Program rocket stages from California to Florida. The aircraft carried the Saturn S-IVB stage, which served as the second stage of the Saturn IB, the third stage of the Saturn V, and the fourth stage for the never-built Nova rocket. This modified KC-97, constructed in 1953, was purchased by NASA in 1997. It is still in service supporting NASA, other Federal agencies, and Federal contractors. It is one of two KC-97s left still in flyable condition, the other being former KC-97G 52-2718, "Angel of Deliverance", flown by Berlin Airlift Historical Foundation as YC-97A 45-59595.

Variants

KC-97A Three C-97As were converted into aerial refueling tankers with rear loading door removed and a flight refueling boom added. After the design was proven, they were converted back into the standard C-97A. KC-97E Company designation Model 367-4-29. Aerial refueling tankers with rear loading doors permanently closed, 60 built. Some were later converted into transports as the C-97E. KC-97F Company designation Model 367-76-29. 3800 hp R-4360-59B engines and minor changes, 159 built. Some were later converted into transport as the C-97F. KC-97G Company designation Model 367-76-66. Dual-role aerial refueling tankers/cargo transportation aircraft. KC-97G models carried underwing fuel tanks. 592 built. EC-97G ELINT conversion of three KC-97Gs. 53-106 was operated by the Central Intelligence Agency for covert ELINT operations in the West Berlin Air Corridor. C-97G 135 KC-97Gs converted to transports. GKC-97G Five KC-97Gs were used as ground instruction airframes. JKC-97G One aircraft was modified to test the underwing General Electric J47-GE-23 jet engines, and was later designated KC-97L. HC-97G KC-97Gs converted for search and rescue operations, 22 converted. KC-97H One KC-97F was experimentally converted into a hose-and-drogue refueling aircraft. YC-97J Company designation Model 367-86-542. Two KC-97G conversion with four 4250 kW Pratt & Whitney YT34-P-5 turboprops, dropped in favour of the Boeing KC-135 Stratotanker. C-97K 27 KC-97Gs converted to troop transports. KC-97L 81 KC-97Gs modified with two J47 turbojet engines on underwing pylons. The codenames "Eager Beaver" and "Rivet Box" were used for Big Safari-built photoreconnaissance modifications to the C-97G for the 7405th Support Squadron along the Berlin air corridors.

Operators

Spain Spanish Air Force (3 ex-USAF, 1972-1976) United States United States Air Force The following USAF wing organizations flew the various KC-97 models at some time during their existence:

Active duty

Air National Guard

== Accidents and incidents == 27 June 1954 KC-97G AF Ser. No. 52-2654 which departed from Altus Air Force Base, Oklahoma, encountered poor weather at its destination, March Air Force Base in California, and attempted to divert to Norton Air Force Base, but crashed into Box Springs Mountain north of Riverside, California, killing all 14 people on board. 4 May 1955 USAF KC-97G 53-0110 was flying in formation when it crashed into the Atlantic 90 mi off Iceland due to loss of control caused by an engine fire, killing all nine on board. 6 July 1956 USAF KC-97E 51-0220 crashed in a wooded area 45 mile northeast of Goose Bay, Canada after reporting an engine fire, killing all six on board. 22 January 1957 a KC-97G AF Ser. No. 53-0222 from Griffiss Air Force Base, New York, crashed in the foothills of the Adirondack Mountains, killing its crew of seven. 9 May 1957 KC-97F AF Ser. No. 51-0258 en route from Sidi Slimane Air Base, Morocco, to Lajes AB, Azores, ditched in the Atlantic 550 km (343.8 mls) SE of the Azores Islands following a double engine failure. All seven crew survived. The airplane floated for ten days before being sunk by the battleship USS Wisconsin. 18 July 1957 KC-97G AF Ser. No. 52-2737 from the 380th Air Refueling Squadron with a crew of eight, exploded and crashed into Lake Champlain at 2128 hrs., when two of the four engines failed three minutes after take-off from Plattsburgh AFB, New York. There were three survivors. 29 October 1957 KC-97G AF Ser. No. 52-2711 of the 509th Bomb Wing, out of Walker AFB, New Mexico, crashed 35 miles north of Flagstaff, Arizona, while on a nine-hour low-level survey flight to determine minimum altitude restrictions for B-47 training routes. The aircraft was seen over Gray Mountain, Arizona, at altitude of 60 feet shortly after 0830 hrs., and then heard striking a cloud-shrouded cliff face, killing 16 crew and strewing wreckage for 200 yards along mountainside. 22 July 1959 KC-97 AF Ser. No. 52-2703 of Pease Air Force Base crashed near Andover, New Hampshire, while on a nighttime training mission; all seven crewmen were killed. 14 December 1959 KC-97G AF Ser. No. 53-0231 of the 384th Air Refueling Squadron, out of Westover AFB, Massachusetts, collided with a B-52 during a refueling mission at an altitude of ~15,000 feet. The aircraft lost the whole left horizontal stabilizer and elevator, the rudder, and the upper quarter of the vertical stabilizer. The crew made a no-flap, electrical power off landing at night at Dow AFB, Maine; seven crew okay. "Spokesmen at Dow Air Force, Bangor, said the B52 [sic] apparently 'crowded too close' and rammed a fuel boom into the tail of a four-engined KC95 [sic] tanker plane." Aircraft stricken as beyond economical repair. Two crew on the B-52 ejected, parachuted safely, and were recovered by helicopters in a snow-covered wilderness area. The bomber and remaining eight crew safely landed at Westover AFB. 30 March 1960 KC-97 AF Ser. No. 51-0363 (Manufacturer's Serial Number 16430) ditched and sank off Cape Canaveral. This particular aircraft was lost due to engine damage caused by hail. The crash resulted in 3 fatalities of the 14 crew. The wreck of the aircraft was discovered in June 2015, in 365 feet of water by divers. 15 April 1960 KC-97G AF Ser. No. 52-0919 of the 307th Air Refueling Squadron, 307th Bomb Wing, crashed on take-off from Lincoln AFB, Nebraska, after the undercarriage collapsed. All 24 on board survived, with two airmen suffering leg fractures and five others with minor cuts and burns. 27 June 1960 KC-97G AF Ser. No. 52-2728 of the 380th Air Refueling Squadron, Plattsburgh AFB, New York, suffered failure of lubrication on an engine impeller shaft during an evening four-hour training mission to refuel a Boeing B-47 Stratojet. During rendezvous at 15,500 feet, the tanker's number one (port outer) powerplant caught fire. As the bomber moved away from the burning tanker, the crew tried unsuccessfully to put out the blaze. The plane went into a spin as the wing failed outboard of the engine; the aircraft crashed on Jonathan Smith Mountain, a hill east of Puzzle Mountain in Newry, Maine. The flash of the fire was seen from as far away as Lewiston and Bridgton. All five crew were killed. Wreckage covering five acres was still there as of 2010. 28 February 1961 KC-97 AF Ser. No. UNKNOWN of Selfridge Air Force Base, MI. Aircraft crashed shortly after take-off due to engine failure. All five crew members were killed. The aircraft struck houses and an ornamental windmill that was a landmark along Gratiot Rd. (M-25), just north of the base. The attached article incorrectly identifies Selfridge AFB as Selfridge ANGB. Selfridge was not transferred to the Air National Guard July 1971. https://www.baaa-acro.com/crash/crash-boeing-kc-97-stratotanker-selfridge-afb-5-killed 10 December 1962 U.S. Air Force Boeing KC-97G Stratofreighter (serial number 52-2685) experienced an in-flight fire, forcing the crew of ten to bail out over Watkins Glen, New York. The aircraft continued flying more than 600 miles before crashing in a remote area near Mistassini Lake, Quebec, Canada. One crew member was killed during the bail-out attempt when his parachute malfunctioned.https://aviation-safety.net/wikibase/333185 5 November 1964 KC-97 AF Ser. No. unknown of Pease Air Force Base crashed on takeoff; all five crewmen were killed. 19 December 1964 USAF KC-97G 52-907 ran off the runway at Ernest Harmon AFB after the pilot landed too far down the runway, killing all five on board. The pilot attempted to abort the landing, but the aircraft struck approach lights and crashed into a pond. 19 January 1969 Wisconsin Air National Guard KC-97L 52-0904 crashed short of the runway at General Mitchell Airport, killing four of 11 on board. 17 September 1971 KC-97G IAF Serial 4X-FPR/033 of the Israeli Air Force, was shot down by Egyptian missiles over Suez, Egypt; seven of eight-man crew were killed.

Surviving aircraft

On display

==== KC-97G ==== 52-895 – Rogue Valley International-Medford Airport in Central Point, Oregon. 52-905 – Wisconsin National Guard Museum at Volk Field Air National Guard Base in Camp Douglas, Wisconsin. 52-2604 – Cleveland I-X Center grounds in Cleveland Ohio. 52-2624 – Florence Air & Missile Museum, Florence Regional Airport, Florence, South Carolina, which is now closed. Following museum closure, parts were used complete the KC-97, AF Ser. No. 53-0335, on display at the Carolinas Aviation Museum. 52-2630 "Zeppelinheim" – National Museum of the United States Air Force at Wright-Patterson Air Force Base near Dayton, Ohio. 52-2697 – Grissom Air Museum at Grissom Air Reserve Base (former Grissom AFB) in Peru, Indiana. 52-2736 – Israeli Air Force Museum adjacent to Beersheba, Israel. 53-151 – Pima Air and Space Museum adjacent to Davis-Monthan Air Force Base in Tucson, Arizona. 53-189 (Spanish Serial Number TK1-3) – Museo del Aire (Spain) at Cuatro Vientos Airport in Madrid, Spain. Former USAF aircraft. 53-198 – Strategic Air Command & Aerospace Museum near Ashland, Nebraska. 53-218 – Minnesota Air National Guard Museum, St. Paul, Minnesota. Displayed in C-97G configuration. 53-230 – Air Mobility Command Museum at Dover Air Force Base, Delaware. 53-240 – Barksdale Global Power Museum at Barksdale Air Force Base, Louisiana. 53-272 – Milestones of Flight Museum, General William J. Fox Airfield, Lancaster, California, which is now closed. 53-282 – Dyess Linear Air Park at Dyess Air Force Base in Abilene, Texas. 53-283 – The Airplane Restaurant adjacent to Peterson Air Force Base and Colorado Springs Municipal Airport in Colorado Springs, Colorado. 53-298 – Museum of Aviation at Robins Air Force Base in Georgia. 53-327 – Whiteman Air Force Base in Knob Noster, Missouri. 53-335 – Carolinas Aviation Museum, north of Charlotte Air National Guard Base at Charlotte-Douglas International Airport in Charlotte, North Carolina. The museum is closed with a planned re-opening in 2022. 53-354 – Castle Air Museum at the former Castle Air Force Base in Atwater, California. 53-360 – Malmstrom Museum, Malmstrom Air Force Base, Montana. Displayed as 52-2638. 53-363 – March Field Air Museum at March Air Reserve Base (former March AFB) in Riverside, California.

Stored

==== KC-97G ==== 52-918 – privately owned in Riverton, Wyoming. 52-2698 – privately owned in Greybull, Wyoming.

==== KC-97L ==== 52-2695 – privately owned in Greybull, Wyoming. 52-2761 – privately owned in Greybull, Wyoming. 53-208 – privately owned in Riverton, Wyoming. 53-265 – privately owned in Riverton, Wyoming. 53-350 – privately owned in Riverton, Wyoming.

== In popular culture == The KC-97 Stratofreighter is shown in both its cargo and tanker tasks in the 1955 film Strategic Air Command, refueling a B-47 in flight, and in the 1957 film Bombers B-52, refueling B-52s.

Specifications (KC-97L)

Data from USAF Museum, FAS: KC-97 StratotankerGeneral characteristics Crew: 6 (aircraft commander, copilot, navigator, flight engineer, radio operator, boom operator) Capacity: 9,000 US gal (7,500 imp gal; 34,000 L) deliverable fuel Length: 117 ft 5 in (35.79 m) Wingspan: 141 ft 2 in (43.03 m) Height: 38 ft 4 in (11.68 m) Wing area: 1,734 sq ft (161.1 m2) Airfoil: root: Boeing 117 (22%); tip: Boeing 117 (9%) Empty weight: 82,500 lb (37,421 kg) Gross weight: 153,000 lb (69,400 kg) Max takeoff weight: 175,000 lb (79,379 kg) Powerplant: 4 × Pratt & Whitney R-4360-59 Wasp Major 28-cylinder air-cooled radial piston engines, 3,500 hp (2,600 kW) each Powerplant: 2 × General Electric J47-GE-23 turbojet engines, 5,790 lbf (25.8 kN) thrust each in pylon mounted pods Propellers: 4-bladed Hamilton Standard constant-speed fully-feathering propellers Performance

Maximum speed: 400 mph (640 km/h, 350 kn) Cruise speed: 230 mph (370 km/h, 200 kn) Range: 2,300 mi (3,700 km, 2,000 nmi) Service ceiling: 30,000 ft (9,100 m)

References

Citations

Bibliography

External links

KC-97 page at the National Museum of the United States Air Force (archived) Boeing KC-97L Stratofreighter - National Museum of the United States Air Force (active) Airworthy KC-97 Angel of Deliverance A Look Back At Tankers - U.S Department of Defense

Full article on Wikipedia ↗